-
21.
Fluxing effect of composite mineral material - cullet on the enamel glass
-
(Coatings. Enamels.)
-
Synthesized enamel glasses based on the Na 2 O - B 2 O 3 - Co 2 O 3 system - SiO 2 , including perlite, nepheline concentrate and broken glass. The physicochemical and technological properties ...
-
22.
Dosed supply of glass cullet in glass container production
-
(Automation and mechanization of production)
-
Dosing schemes for own and imported cullet based on one- and two-component dosing complexes and a proportional continuous batcher are considered. Il. 3, bibliography: 2 titles.
-
23.
Cullet-containing ceramic masses for ornamental majolica
-
(Utilization of waste)
-
Possibilities of decreasing porosity and increasing mechanical strength of majolica masses based on clays of the Gzhel deposit with additives of 3 - 10% of broken glass have been studied. The ceramic properties ...
-
24.
A system of batch and cullet dosed supply into glass melting furnace
-
(Automation and mechanization of production)
-
Possible variants of the schemes for the dosed supply of the charge and breakage into the glass-making furnace are presented. The features of the use of discrete and continuous strain gauge weighing batchers ...
-
25.
The effect of the redox potentials of the glass batch and cullet on the dye of commercial glass containing iron oxides
-
(Science for glass production)
-
The influence of the redox potentials (ORP) of charges and glass breakage on the color of glasses of industrial compositions containing up to 0.5% iron oxides has been investigated. The boundaries of the ...
-
26.
The reasons for glass mass coloring in conditions of using maximum amount of cullet
-
(Industrial experience)
-
Coloration of glass obtained using the maximum amount of cullet has been studied. The possibility of producing large batches of glass for construction purposes from glass production waste has been confirmed, ...
-
27.
Technological, energy, and environmental aspects of collecting and using cullet
-
(Environmental protection)
-
Shown is the state of affairs in the collection, preparation and use of cullet abroad and in the CIS. Information about cullet obtained from glass factories in Russia and the CIS is summarized. Tab. 3, ...
-
28.
Cullet-Based Structural Materials
-
(Saving the resources and optimal use of raw materials)
-
The results of research on the development of decorative-facing, heat- and sound-insulating building materials based on cullet are presented. The operational parameters of the samples were determined, ...
-
29.
STUDY OF PHOSPHOGYPSUM HEAT TREATMENT MODES FOR OBTAINING ULTRAVIOLET PIGMENTS
-
(Not-set)
-
The paper investigates the possibility of thermal processing of waste from the chemical industry – phosphogypsum. It is shown that when phosphogypsum is dried, partial dehydration of dihydrous calcium ...
-
30.
SYNTHESIS OF POROUS MATERIALS BASED ON TPP ASH-SLAG WASTE USING “SELF-FOAMING” TECHNOLOGY
-
(Not-set)
-
The peculiarities of obtaining porous materials based on different types of ash and slag materials (fly ash, boiler slag, ash-slag mixture) by the “self-foaming” technology using Na2B4O7 flux were studied. ...
-
31.
ANALYSIS OF THE INFLUENCE OF BORATE AND FLUORIDE FLUXES ON THE SINTERING OF SILICATE RAW MATERIALS
-
(Not-set)
-
The effectiveness of using borate (borax) and fluoride (sodium fluoride) fluxes in the sintering of crystalline (sand) and amorphous (diatomite) silicate raw materials was considered. The change in the ...
-
32.
INFLUENCE OF WASTE GLASS POWDER ON THE PROPERTIES OF CERAMIC STAB BASED ON LESS ROCK
-
(Not-set)
-
It was found that it is possible to obtain high-strength ceramic paving stones based on loess rocks with the addition of 20 % glass waste powder. At the same time, the amount of moisture in the ation should ...
-
33.
ENVIRONMENTAL ASPECTS OF THE USE OF BATTLE GLASS FOR THE PRODUCTION OF GLASS CONCRETE
-
(Not-set)
-
The technology of glass concrete based on dispersed container and sheet glass has been developed. It is shown that when Portland cement and cullet are ground together, when a specific surface area of 5890 ...
-
34.
GURLEN HYDROSLUIDIC CLAY IS A LOW-TEMPERATURE FLUX IN THE PRODUCTION OF CERAMICS
-
(Not-set)
-
As a result of a comprehensive study of the characteristics of the clay of the Gurlensky deposit, it was determined that the Gurlensky hydrosluidic clay, in its chemical composition, has a relatively high ...
-
35.
PRODUCTION OF GLASS FOAMS ON THE BASIS OF ROCKS
-
(Not-set)
-
The results of research on the production of granular and block foam glass materials based on widespread highly siliceous rocks and technogenic waste are presented. The main attention of researchers is ...
-
36.
CARBON FOOTPRINT OF THE LIFE CYCLE OF GLASS CONTAINER
-
(Not-set)
-
... a period of 5 years (12 recycling units) was carried out for two ways of recycling glass containers: involving 20 % of cullet and washing salvage glass containers. A graphical comparison of the calculation ...
-
37.
INFLUENCE OF LIQUID FOAMING AGENT DISTRIBUTION ON THE FORMATION OF FOAM GLASS POROUS STRUCTURE
-
(Not-set)
-
It was shown that the use of liquid-phase foaming agents is promising for the synthesis of foam glass. The dynamics of the change in the glass particles size in the process of batch obtaining was studied. ...
-
38.
STUDY OF THE POSSIBILITY OF OBTAINING THERMAL INSULATING MATERIALS USING ASH WASTE
-
(Not-set)
-
The possibility of obtaining inorganic block heat-insulating foams based on silica and ash-containing man-made waste is considered. The influence of modifying additives and technological modes on the structure ...
-
39.
The Influence of Nepheline Syenite and Waste of Mineral Wool Production on the Operational Properties of Ceramics
-
(Not-set)
-
The possibility of using wastes from the production of mineral wool (MB) and nepheline-syenite (NS) in the production of ceramics in order to improve the physical and mechanical properties of the samples, ...
-
40.
Technological Aspects of Using Glass Mass Granulators in Production of Different Glass Products
-
(Not-set)
-
Various designs of molten glass granulators used in the production of glass containers and other glass products are considered. The main advantages and disadvantages of such equipment installed in the ...
